PB1506PFC [VICOR]
AC-DC Power Factor Correction Module, 2 Output, 600W, Hybrid, MODULE-15;型号: | PB1506PFC |
厂家: | VICOR CORPORATION |
描述: | AC-DC Power Factor Correction Module, 2 Output, 600W, Hybrid, MODULE-15 |
文件: | 总4页 (文件大小:113K) |
中文: | 中文翻译 | 下载: | 下载PDF数据表文档文件 |
Data Sheet
Power Bank PB1506PFC
AC/DC Power Supply
6 Main Outputs, 1500W
5V and 12/24V Auxiliary Outputs
Low-Profile 1.75" (1U)
All specifications are at nominal input, full load, 25°C, unless otherwise noted.
Input
Input Voltage Range
Input Frequency
85-264VAC or 250-374Vdc
47-63 Hz (400Hz1)
<60 A
Inrush Current (264 VAC peak line, cold start.)
Input Fuse
Power Factor (minimum)
20A (internal)
0.95
Front or Rear Panel Mounted
Power Switch
Output
Output
A
80A
1.8 to 52 V
Maxi
B
80A
1.8 to 52 V
Micro
C
D
E
40A
F
Maximum Output Current (Connector Limit)
Output Voltage (Factory configurable)
Module Size
1.8 to 52 V
Micro
1.2%
Mini
Output Voltage Setpoint (50% load)
Load Regulation, No load to full load (max.)
Line Regulation, Low Line to High Line (max.)
1.2%
1.2%
0.2%
0.2%
Yes
1.2%
0.5%
0.5%
No
0.25%
0.2%
0.5%
0.5%
Remote Sense
Yes
Yes
No
Yes
Output Trim
Yes
1%
Yes
1.5%
150W
Output Ripple and Noise (typ.) 20MHz BW
Maximum Output Power (Individual Output)
1%
1.5%
150 W
600W
300W
Maximum Output Power
(All Outputs Combined)
1,500W at 180 to 264VAC input voltage (up to 40°C)
Derate: 8W per Volt below 180VAC, 50W per °C above 40°C
Environmental
Operating Temperature Range
Thermal Shutdown
-20°C to 70°C
80°C on the internal heatsink, latching
-40°C to 70°C
Storage Temperature Range
Relative Humidity
5% -95% non-condensing
Safety
Agency Approvals
cTUVus, CE
EN60950
3,000 Vrms
1,500 Vrms
250 Vrms
Safety Standard Compliance
Isolation, Primary-to-Secondary
Isolation, Primary-Earth
Isolation, Secondary-Earth
1 Unit will operate from 400 Hz, but may not meet Power Factor Specifications
Vicor Custom Power - Northwest
(503)-652-6161
www.npi-inc.com
Document No. 4007 Rev B
Print Date: 2012-05-03
Page 1 of 4
PB1506PFC
EMI and EMC
Conducted Noise
EN55022 Class A (150kHz-30MHz)
16.84" x 12.6" x 1.75"
Mechanical
Dimensions
(Approximate. See Mechanical Drawing for details.)
Mounting Brackets
19" Front Panel
Internal Fans
Mounting Options (contact factory for details)
Cooling
Weight (Typical, depends on configuration)
14 lb. (6.4 kg)
Mechanical Drawing
LEDs
A
D
E
F
B
C
Molex, 4 pin
MiniFit Senior
42820-4212
(3 Places)
Molex, 2 pin
MiniFit Senior
42820-2212
(2 Places)
Molex 3 pin
0.120” Pocket
70555-0037
(6 Places)
AMP, 10 pin
0.120” Pocket
103673-9
IEC-320
Vicor Custom Power - Northwest
(503)-652-6161
www.npi-inc.com
Document No. 4007 Rev B
Print Date: 2012-05-03
Page 2 of 4
PB1506PFC
Connections
Input
Connector
Details
IEC320
Standard pin configuration
Output Power Connections for Channels A and B
Details
Straigth Busbar
(Option -B)
Pin
Signal Description
Molex Minifit Sr. Connector
(Option -M)
Right-Angle Busbar
(Option -R)
1
2
3
4
Positive Terminal, 49A max
Positive Terminal,
Tapped 1/4-20 hole,
100A max
+
+
-
Positive Terminal, 1/4"
hole, 100A max
Positive Terminal, 49A max
Negative Terminal, 49A max
Negative Terminal, 49A max
Negative Terminal,
Tapped 1/4-20 hole,
100A max
Negative Terminal,
1/4" hole, 100A max
-
Output Power Connections for Channels C and D
Signal Description
Pin
Details
1
Positive Terminal, 20A max
+
-
2
Negative Terminal, 20A max
Output Power Connections for Channels E and F
Signal Description
Pin
Details
1
Output E, Positive Terminal, 20A max
+
-
+
-
2
3
4
Output E, Negative Terminal, 20A max
Output F, Positive Terminal, 20A max
Output F, Negative Terminal, 20A max
Vicor Custom Power - Northwest
(503)-652-6161
www.npi-inc.com
Document No. 4007 Rev B
Print Date: 2012-05-03
Page 3 of 4
PB1506PFC
Trim/Remote Sense Connections for Channels A and B
(Remote sense is active only if Maxi or Mini size module is installed.)
Pin
Signal Description
Details
Positive Sense Connection
(Internally connected to positive output through 10 Ω resistor fused by 0.17A Polyfuse)
1
+
Trim
-
2
3
Connect this pin with a resistor to Pin 1 for trim up, or to Pin 3 for trim down.
Negative Sense Connection
(Internally connected to negative output through 10 Ω resistor)
Trim Connections for Channels C,D,E and F
Signal Description
Pin
Details
1
(Internally connected to positive output through 0.17A Polyfuse)
+
Trim
-
2
3
Connect this pin with a resistor to Pin 1 for trim up, or to Pin 3 for trim down.
Connected directly to negative output.
Note: All control signals are isolated; Input - 3,000 Vrms; Output - 250 Vrms; Chassis - 250 Vrms
I/O Connections
Pin
Signal Description
Details
1
Output A Inhibit
Output B Inhibit
Output C Inhibit
Output D Inhibit
Output E Inhibit
Output F Inhibit
Pgood
2
3
4
5
6
7
Connect to Pin 10 to inhibit output.
Open-circuit voltage 5V.
Short-circuit current 1mA.
Open Collector, 40V/5mA, Active Low = Power Good
8
Aux Output
Configurable: No Output, 12V, or 24V
1A max current
combined
9
5VSB (Stand-By) Output
Control Return
5V
Reference for all signals on I/O connector
Return for Aux and 5VSB ouputs
10
One Red/Green LED for each main output
Front Panel LEDs
Color
Signal Description
Details
Corresponding output voltage is correct, i.e. sufficiently high if
output is populated or zero if output is not populated.
Green
Red
Output OK
Output Not OK
Corresponding output voltage is too low.
Information furnished by NPI is believed to be accurate and reliable. However, no responsibility is assumed by NPI or Vicor for its use. No license is
granted by implication or otherwise under any patent or patent rights of NPI or Vicor. NPI products are not designed to be used in applications, such as
life support systems, wherein a failure or malfunction could result in injury or death. All sales are subject to NPI 's Terms and Conditions of Sale, which
are available upon request.
Specifications are subject to change without notice.
Vicor Custom Power - Northwest ♦ 4211 SE International Way, Suite F♦ Milwaukie, OR, USA
Tel: 503-652-6161 ♦ Fax: 503-652-6868 ♦ www.npi-inc.com
Vicor Custom Power - Northwest
(503)-652-6161
www.npi-inc.com
Document No. 4007 Rev B
Print Date: 2012-05-03
Page 4 of 4
PB1506PFC
相关型号:
©2020 ICPDF网 联系我们和版权申明