HDH40-48D-S150027 [HITRON]

ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT; 内置DC -DC转换器底板的电源模块工业级40瓦单个与多个输出


型号：	HDH40-48D-S150027
厂家：	HITRON ELECTRONICS CORPORTION
描述：	ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT 内置DC -DC转换器底板的电源模块工业级40瓦单个与多个输出转换器电源电路输出元件 DC-DC转换器
文件：	总2页 (文件大小：400K)
中文：	中文翻译
下载：	下载PDF数据表文档文件

H HiTRON

ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE

INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT

HDH40-24D OR 48D-S, D, T SERIES

FEATURES:

ꢀ

SINGLE, DUAL & TRIPLE OUTPUT

4:1 ULTRA-WIDE INPUT VOLTAGE

1,500VDC ISOLATION

HEATSINK MOUNT FORMAT

INDUSTRIAL STANDARD PIN-OUT

UNDER-VOLTAGE LOCKOUT

SPECIFICATION

INPUT SPECIFICATION

OUTPUT SPECIFICATION

Output Voltage: See Ratings Chart.

Input Range/Voltage: Ultra-wide 4:1 Range.9-36Vdc for

24Vdc nominal input.

Output Current: See Ratings Chart.

Range 18-72Vdc for 48Vdc nominal input.

Input Current: Various with input range & load.

See Ratings Chart.

Voltage Accuracy: Typ. main O/P ±1.0%,Aux. O/P ±2.0%.

Line Regulation: Various with input & output voltage.

±0.5% typical.

Input Fuse: Use external fuse.

Load Regulation: Various with output voltages

Single O/P: VO1±1.0% typical.

Input Filter: Pi-Network.

Undervoltage Drop Out: 12Vdc typical.

Isolation Resistor: 1,000 Mega Ohms.

Isolation Voltage: 1,500Vdc for input to output.

1,500Vdc for input to case and output to case.

Shielding: Five-sided.

Dual O/P: VO1 ±1.0% & VO2 ±2.0% typical.

Triple O/P: VO1 & VO3 ±2.0%, VO2 ±5.0% typical.

Noise & Ripple: 100mV for 3.3V/5.0V & 1.0% typical

for others output peak to peak.

OVP: Built-in on main output.

Remote On/Off: TTL/CMOS-Compatible input control.

Positive Logic version for Standard set up:

ON(Enable)=Open(or 2.5-5.0Vdc above-Vin)

OFF(Disable)=Short(or 0-0.8Vdc above-Vin)

Negative Logic version option available by adding a

Adjustability: VO1O/P may optionally be external trimmed

±3.0% with a fixed resistors or trim-pot.

Overload Protection (OLP):

Fully protected against overload and short circuit.

OLP set at about 125-150% max. load.

Consult factory for special OLP setting.

“N” suffix to the end of Model #.

Remark: [Voltage refer to –Input (-Vin)]

GENERAL SPECIFICATION

Efficiency: 75-79% typical, various with input &

output voltages.

Operating Temperature: -40 to +100°C. (Base plate).

Power derating details, please refer to the Derating Chart.

Storage Temperature: -55 to +125°C.

Switching Frequency: Fixed frequency 250K Hz.

Circuit Topology: Forward Circuit.

Temperature Coefficient: ±0.02%/°C.

Transient Response: Peak deviation 200mV,

Recovery time <3mSec. @ 25% step load change.

Case: Aluminum base plate.

Cooling: At least 100LFM moving air is recommended for

full load > +25°C room temperature in a confined area.

Air flow vs. Power derating details, please refer to the

Derating Chart.

Power Density: 7.5 Watts / Cubic inch.

MTBF: 1,000,000 hours, Mil.Std.271, 25°C.

Industrial Grade only.

NOTE: (1) All measurements are at nominal input, full load, and +25°C unless otherwise specified.

(2) Line Regulation measured from High to Low Lines at full load.

(3) Load Regulation measured from Full-Load (F-L) to Half-Load(H-L)at nominal input.

(4) Correct fuse size by calculating the max. DC current drain at low Line input & adding 20-25% for desired fuse size.

Due to requests in market and advances in technology, specifications subject to change without notice.

-33-

INPUT/OUTPUT & VOLTAGE/CURRENT RATINGS CHART

SINGLE OUTPUT

VO1 ★@#

INPUT Vdc

Range

MODEL NO.

Nom.

24Vdc

48Vdc

TYP.

VOLT.

3.3V

9-36Vdc

18-72Vdc

7.6A

8.0A

3.4A

2.7A

2.3A

7.6A

8.0A

3.4A

2.7A

2.3A

HDH40-24D-S033076

HDH40-24D-S050080

HDH40-24D-S120034

HDH40-24D-S150027

HDH40-24D-S180023

HDH40-48D-S033076

HDH40-48D-S050080

HDH40-48D-S120034

HDH40-48D-S150027

HDH40-48D-S180023

5.0V

12.0V

15.0V

18.0V

3.3V

5.0V

12.0V

15.0V

18.0V

DUAL OUTPUT

MAIN VO1 ★@

AUX. VO2

INPUT Vdc

MODEL NO.

Range

Nom.

24Vdc

48Vdc

TYP.

1.67A

1.35A

1.67A

1.35A

TYP.

VOLT.

+12.0V

+15.0V

+12.0V

+15.0V

VOLT.

-12.0V

-15.0V

-12.0V

-15.0V

9-36Vdc

18-72Vdc

1.67A

1.35A

1.67A

1.35A

HDH40-24D-D120I

HDH40-24D-D150K

HDH40-48D-D120I

HDH40-48D-D150K

TRIPLE OUTPUT

MAIN VO1 ★@

AUX. VO2

AUX. VO3

INPUT Vdc

MODEL NO.

Range

9-36Vdc

18-72Vdc

Nom.

24Vdc

48Vdc

TYP.

4.0A

TYP.

0.84A

0.67A

0.84A

0.67A

TYP.

VOLT.

5.0V

VOLT.

+12.0V

+15.0V

+12.0V

+15.0V

VOLT.

-12.0V

-15.0V

-12.0V

-15.0V

0.84A

0.67A

0.84A

0.67A

HDH40-24D-T050II

HDH40-24D-T050KK

HDH40-48D-T050II

5.0V

18-72Vdc

5.0V

HDH40-48D-T050KK

Symbols: "★" OVP built-in.

"@" Adjustable.

"#" Remote sensing.

MECHANICAL DIMENSIONS: MM [INCHES]

WEIGHT: 145.8g (5.13 Oz.)

PIN ASSIGNMENT

PIN NO.

PIN# 1.

SINGLE

REMOTE

ON/OFF

CASE

DUAL

REMOTE

ON/OFF

CASE

+Vin

TRIPLE

REMOTE

ON/OFF

CASE

PIN# 2.

PIN# 3.

PIN# 4.

PIN# 5.

PIN# 6.

PIN# 7.

PIN# 8.

PIN# 9.

PIN# 10.

+Vin

-Vin

No Pin

DC COM

+VO1

Trim

No Pin

N/C

-VO2

DC COM

+VO1

Trim

No Pin

-VO3

+VO2

DC COM

+VO1

TRIM

DERATING CHART

-34-

相关型号：

HDH40-48D-S180023

ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT

HITRON

HDH40-48D-T050II

ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT

HITRON

HDH40-48D-T050KK

ON-BOARD DC-DC CONVERTER BASE PLATE POWER MODULE INDUSTRIAL GRADE 40 WATTS SINGLE & MULTIPLE OUTPUT

HITRON